900,000+ datasheet pdf search and download

Datasheet4U offers most rated semiconductors data sheet pdf




Sony Semiconductor Electronic Components Datasheet

HCD-MX500i Datasheet

COMPACT DISC RECEIVER SERVICE MANUAL

No Preview Available !

HCD-MX500i/MX550i
SERVICE MANUAL
Ver. 1.0 2010.05
Canadian Model
Chinese Model
Singapore Model
HCD-MX500i
AEP Model
HCD-MX500i/MX550i
UK Model
HCD-MX550i
Photo: HCD-MX550i
• HCD-MX500i is the amplier, CD player, tuner, USB (Except Canadian) and iPod/iPhone section in CMT-MX500i.
• HCD-MX550i is the amplier, CD player, tuner, USB and iPod/iPhone section in CMT-MX550i.
• iPod is a trademark of Apple Inc.
• iPhone is a trademark of Apple Inc.
• MPEG Layer-3 audio coding technology and patents licensed from Fraunhofer IIS and Thomson.
• Windows Media is either a registered trademark or trademark of Microsoft Corporation in the
United States and/or other countries.
• This product is protected by certain intellectual property rights of Microsoft Corporation. Use or
distribution of such technology outside of this product is prohibited without a license from Micro-
soft or an authorized Microsoft subsidiary.
• All other trademarks and registered trademarks are of their respective holders. In this manual, ™
and ® marks are not specied.
Model Name Using Similar Mechanism
CD Mechanism Type
Optical Pick-up Block Name
NEW
CDM85CD-DVBU102
KHM-313CAA
SPECIFICATIONS
Main unit
AUDIO POWER SPECIFICATIONS
With 6 ohm loads, both channels driven, from 120 10,000 Hz; rated 30 watts
per channel minimum RMS power, with no more than 10% total harmonic
distortion from 250 milliwatts to rated output.
Amplifier section
European model:
DIN power output (rated): 25 watts + 25 watts (6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference): 30 watts + 30 watts (6 ohms at
1 kHz, 10% THD)
Music power output (reference): 30 watts + 30 watts (6 ohms at 1 kHz, 10%
THD)
Other models:
DIN power output (rated): 25 watts + 25 watts (6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference): 30 watts + 30 watts (6 ohms at
1 kHz, 10% THD)
Input
AUDIO IN (stereo mini jack): Sensitivity 700 mV, impedance 47 kilohms
Outputs
SPEAKERS: Accepts impedance of 6 ohms
CD player section
System: Compact disc and digital audio system
Laser Diode Properties
Emission Duration: Continuous
Laser Output*: Less than 44.6μW
* This output is the value measurement at a distance of 200mm from the
objective lens surface on the Optical Pick-up Block with 7mm aperture.
Frequency response: 20 Hz 20 kHz
Signal-to-noise ratio: More than 90 dB
Dynamic range: More than 90 dB
Tuner section
FM tuner section:
FM stereo, FM superheterodyne tuner
Tuning range:
North American model: 87.5 MHz 108.0 MHz (100 kHz step)
Other models: 87.5 MHz 108.0 MHz (50 kHz step)
Antenna: FM lead antenna
Antenna terminals: 75 ohms unbalanced
Intermediate frequency: 10.7 MHz
DAB/DAB+ tuner section (MX550i only):
FM stereo, DAB/FM superheterodyne tuner
Frequency range*
Band-III: 174.928 (5A) MHz 239.200 (13F) MHz
* For details, see “DAB/DAB+ frequency table” below.
Antenna: DAB/FM lead antenna
Antenna terminal: 75 ohms, F female
DAB/DAB+ frequency table (Band-III)
Frequency
174.928 MHz
176.640 MHz
178.352 MHz
180.064 MHz
181.936 MHz
183.648 MHz
185.360 MHz
187.072 MHz
188.928 MHz
190.640 MHz
192.352 MHz
194.064 MHz
195.936 MHz
197.648 MHz
199.360 MHz
201.072 MHz
202.928 MHz
204.640 MHz
206.352 MHz
208.064 MHz
Label
5A
5B
5C
5D
6A
6B
6C
6D
7A
7B
7C
7D
8A
8B
8C
8D
9A
9B
9C
9D
Frequency
209.936 MHz
211.648 MHz
213.360 MHz
215.072 MHz
216.928 MHz
218.640 MHz
220.352 MHz
222.064 MHz
223.936 MHz
225.648 MHz
227.360 MHz
229.072 MHz
230.784 MHz
232.496 MHz
234.208 MHz
235.776 MHz
237.488 MHz
239.200 MHz
Label
10A
10B
10C
10D
11A
11B
11C
11D
12A
12B
12C
12D
13A
13B
13C
13D
13E
13F
* Frequencies are displayed to two decimal places on this system.
iPod/iPhone section
Compatible iPod/iPhone models:
iPod touch 2nd generation
iPod touch 1st generation
iPod classic 120 GB, 160 GB (2009)
iPod classic 160 GB (2007)
iPod classic 80 GB
iPod nano 5th generation (video camera)
iPod nano 4th generation (video)
iPod nano 3rd generation (video)
iPod nano 2nd generation (aluminum)
iPod nano 1st generation
iPod 5th generation (video)
iPod 4th generation (color display)
iPod 4th generation
iPod mini
iPhone
iPhone 3G
iPhone 3GS
USB section (except for North American model)
Supported bit rate:
MP3 (MPEG 1 Audio Layer-3): 32 kbps 320 kbps, VBR
WMA: 48 kbps 192 kbps, VBR
AAC: 48 kbps 320 kbps
Sampling frequencies:
MP3 (MPEG 1 Audio Layer-3): 32/44.1/48 kHz
WMA: 44.1 kHz
AAC: 44.1 kHz
(USB) port: Type A, maximum current 500 mA
General
Power requirements:
North American model: AC 120 V,60 Hz
Other models: AC 220 V 240 V, 50/60 Hz
Power consumption: 33 watts
Dimensions (W/H/D) (excl. speakers):
Approx. 309 mm × 122 mm × 247 mm
Mass (excl. speakers): Approx. 2.9 kg
Design and specifications are subject to change without notice.
Standby power consumption: 0.5 W
Halogenated flame retardants are not used in the certain printed
wiring boards.
COMPACT DISC RECEIVER
9-889-872-01
2010E05-1
© 2010.05
Sony Corporation
Audio&Video Business Group
Published by Sony Techno Create Corporation


Sony Semiconductor Electronic Components Datasheet

HCD-MX500i Datasheet

COMPACT DISC RECEIVER SERVICE MANUAL

No Preview Available !

HCD-MX500i/MX550i
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be dam-
aged by heat.
FLEXIBLE CIRCUIT BOARD REPAIRING
• Keep the temperature of soldering iron around 270 °C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
Laser component in this product is capable of emitting radiation
exceeding the limit for Class 1.
This appliance is classied as
a CLASS 1 LASER product.
This marking is located on the
rear or bottom exterior.
SAFETY-RELATED COMPONENT WARNING!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONC-
TIONNEMENT. NE REMPLACER CES COMPOSANTS QUE
PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DON-
NÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
TABLE OF CONTENTS
1. SERVICING NOTES ............................................. 3
2. DISASSEMBLY
2-1. Disassembly Flow........................................................... 8
2-2. Case................................................................................. 8
2-3. Front Panel Block ........................................................... 9
2-4. Knob (VOL).................................................................... 10
2-5. MAIN Board ................................................................... 10
2-6. SP Board ......................................................................... 11
2-7. POWER Board................................................................ 11
2-8. CD Block ........................................................................ 12
2-9. BD96/BD96U Board....................................................... 13
2-10. Belt.................................................................................. 13
2-11. FFC Holder ..................................................................... 14
2-11. Optical Pick-up Block (KHM-313CAA)........................ 14
3. TEST MODE ............................................................ 15
4. ELECTRICAL CHECK ......................................... 18
5. DIAGRAMS
5-1. Block Diagram - CD, USB Section -.............................. 19
5-2. Block Diagram
- TUNER, iPod/iPhone, AUDIO IN Section - ................ 20
5-3. Block Diagram - OUTPUT, PANEL Section - ............... 21
5-4. Block Diagram - POWER SUPPLY Section -................ 22
5-5. Printed Wiring Board
- BD96/BD96U Board (Side A) - ................................... 24
5-6. Printed Wiring Board
- BD96/BD96U Board (Side B) - ................................... 25
5-7. Schematic Diagram - BD96/BD96U Board (1/2) - ........ 26
5-8. Schematic Diagram - BD96/BD96U Board (2/2) - ........ 27
5-9. Printed Wiring Board - DAB Board (MX550i) -............ 28
5-10. Schematic Diagram - DAB Board (MX550i) -............... 29
5-11. Printed Wiring Board - MAIN Board (1/2) - .................. 30
5-12. Printed Wiring Boards - MAIN Board (2/2) -................. 31
5-13. Schematic Diagram - MAIN Section (1/4) -................... 32
5-14. Schematic Diagram - MAIN Section (2/4) -................... 33
5-15. Schematic Diagram - MAIN Section (3/4) -................... 34
5-16. Schematic Diagram - MAIN Section (4/4) -................... 35
5-17. Printed Wiring Boards - IP/JACK/SP/USB Boards - ..... 36
5-18. Schematic Diagram - IP/JACK/SP/USB Boards -.......... 37
5-19. Printed Wiring Boards - PANEL Section - ..................... 38
5-20. Schematic Diagram - PANEL Section -.......................... 39
5-21. Printed Wiring Board - POWER Board -........................ 40
5-22. Schematic Diagram - POWER Board - .......................... 41
6. EXPLODED VIEWS
6-1. Case Section.................................................................... 54
6-2. Front Panel Section......................................................... 55
6-3. iPod Dock Section .......................................................... 56
6-4. MAIN Board Section ...................................................... 57
6-5. Chassis Section ............................................................... 58
6-6. CD Mechanism Deck Section
(CDM85CD-DVBU102) ................................................ 59
7. ELECTRICAL PARTS LIST .............................. 60
2


Part Number HCD-MX500i
Description COMPACT DISC RECEIVER SERVICE MANUAL
Maker Sony
Total Page 30 Pages
PDF Download

HCD-MX500i Datasheet PDF

View PDF for Mobile








Similar Datasheet

1 HCD-MX500i COMPACT DISC RECEIVER SERVICE MANUAL
Sony





Part Number Start With

0    1    2    3    4    5    6    7    8    9    A    B    C    D    E    F    G    H    I    J    K    L    M    N    O    P    Q    R    S    T    U    V    W    X    Y    Z

Site map

Webmaste! click here

Contact us

Buy Components

Privacy Policy